Product ID:CADOX BS
MSDS Date:07/06/1994
FSC:6810
NIIN:00N069394
MSDS Number: CDWRP

AKZO NOBEL CHEMICALS INC

300 SOUTH RIVERSIDE PLAZA
CHICAGO, IL 60606
US

Emergency Phone: 914-693-6946;800-424-9300(CHEMTREC)

Info Phone: 914-693-6946

Cage: 97854

AKZO NOBEL CHEMICALS INC

CHICAGO, IL 60606-6613 US

Telephone: 800-828-792

Cage: 97854

BENZOYL PEROXIDE (SARA 313)

CAS: 94-36-0

RTECS: DM8575000

Fraction By Weight: 50%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA

CAS: 84-74-2

RTECS: TI0875000

Fraction By Weight: 2%

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

POLY (DIMETHYLSILOXANE)

CAS: 63148-62-9

RTECS: JJ6484500

Fraction By Weight: 40-50%

OSHA PEL N/K

ACGIH TLV: N/K

SILICA, FUMED.

CAS: 7631-86-9

Fraction By Weight: 0.5-3%

OSHA PEL N/K

ACGIH TLV: N/K

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Fraction By Weight: 0.5-2%

OSHA PEL N/K

ACGIH TLV: N/K

GIVE ANYTHING BY MOUTH TO PERSON WHO IS

RTECS: 9999999ZZ

AIRWAY. IF BRTHG STOPS, BEGIN ARFT RESP IMMED. IF

RTECS: 9999999ZZ

NO SPECIFIC

RTECS: 9999999ZZ

MD'S JUDGMENT SHOULD BE USED TO CONTROL SYMPS &

RTECS: 9999999ZZ

OF UNKNOWN CONC OF GAS/VAP SHOULD USE NIOSH

RTECS: 9999999ZZ

CONTAINED BREATHING APPARATUS. PROTECTIVE EQUIPMENT

RTECS: 9999999ZZ

UP LIQUID W/SUITABLE ABSORBENT SUCH AS CLAY, SAND

RTECS: 9999999ZZ

CHEMICAL WASTE CONTAINER FOR DISPOSAL.

RTECS: 9999999ZZ

APPLICABLE FEDERAL, STATE AND LOCAL LAWS

RTECS: 9999999ZZ

EMER TEMP IS DERIVED FROM SADT. KEEP

RTECS: 9999999ZZ

(EG AMINES, ACIDS, ALKALIS) & HEAVY METAL COMPOUNDS

RTECS: 9999999ZZ

SHOULD NOT BE OPENED UNTIL READY FOR USE. USE CLEAN

RTECS: 9999999ZZ

TRANSFERRING TO PREVENT ACCUMULATION OF STATIC

RTECS: 9999999ZZ

CONTAINER MAY RETAIN PROD RESIDUES. FOLLOW ALL

RTECS: 9999999ZZ

CAUSES EYE IRRITATION. MAY CAUSE SKIN IRRITATION.

RTECS: 9999999ZZ

AND VAPORS. OVEREXPOSURE MAY CAUSE CNS DEPRESSION

RTECS: 9999999ZZ

AREA) IS NOT AVAILABLE. WHERE EXPOSURE POTENTIAL

RTECS: 9999999ZZ

NIOSH APPROVED, POSITIVE-PRESSURE/PRESSURE-DEMAND,

RTECS: 9999999ZZ

CARTRIDGES OR CANISTERS, THEY MUST BE CHANGED

RTECS: 9999999ZZ

ASSURE BREAKTHROUGH EXPOSURE DOES NOT OCCUR.

RTECS: 9999999ZZ

LD50 LC50 Mixture:LD50:(ORAL,RT) >5000 MG/KG
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION:RESPIRATORY
IRRITATION. SKIN:WAS POSITIVE IN A HUMAN SKIN SENSITIZATION STUDY.
MILD IRRITATION, DEFATTING, DERMATITIS AND MAY CAUSE SENSITIZATION.
EYE:SLIGHT IRRITANT TO RABBIT EYES. TARGET ORGANS:OVEREXPOSURE TO
PRODUCT MAY AFFECT THE SKIN AND EYES. CONTACT NEHC FOR MORE INFO ON
HLTH HAZS .
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISEASE.

First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE O*2/ARTF RESP)
. EYES:IMMED FLUSH W/POTABLE WATER FOR MINIMUM OF 15 MINS, SEEK
ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMTS OF WATER. CALL MD .
INGEST:IMMED GIVE SEVERAL GLASSES OF WATER. DO NOT INDUCE VOMIT. IF
VOMIT OCCURS, KEEP HEAD BELOW HIPS TO REDUCE RISK OF ASPIR. GIVE
FLUIDS AGAIN. HAVE PHYS DETERM IF CNDTN OF (SUPDAT)

Flash Point Method:SCC
Flash Point:>199F,>93C
Extinguishing Media:WATER FOG, DRY CHEM, CARBON DIOXIDE/FOAM. LG
FIRES:LARGE AMTS OF WATER SPRAY, FOG/FOAM FROM SAFE/PROTECTED
POSITION.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . PVNT
HUMAN EXPOS. EVAC NONESSTNL PERS. IF POSS, MOVE CNTNRS FROM FIRE
AREA. IF NOT LEAKING, KEEP FIRE EXPOS (SUPDAT)
Unusual Fire/Explosion Hazard:TOX & FLAMM VAPORS MAY BE PRODUCED UNDER
COMBUSTION. ISOLATE FROM SOURCES OF IGNITION. FLAMM VAPORS MAY
TRAVEL TO SOURCE OF IGNITION AND FLASH BACK.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT FROM SPILL AREA.
STOP SOURCE OF SPILL. IF TOOLS ARE NEEDED, THEY SHOULD BE
NON-SPARKLING. DIKE AREA TO PVNT SPILL FROM SPREADING. EVAC ALL
NON-ESSTNL PERS UPWIND. ANY PERSO N ENTERING AN AREA OF SIGNIFICANT
SPILL/ (ING 10)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:TO INSURE PROD QUALITY, STOR TEMPS NOT
>86F (30C). TO INSURE AGAINST POSS EXOTHERMIC SELF ACCELERATING
DECOMP, STOR TEMPS NOT >131F(55C). THIS(ING 15)
Other Precautions:WEAR PROT CLTHG TO AVOID EYE & SKIN CNTCT. WASH
THOROUGHLY AFTER HNDLG. ELEC GROUNDED TANKS & CNTNRS SHOULD ALWAYS
BE USED AS SHOULD NON-SPKG, ELEC GROUNDED HAND TOOLS & APPLIANCES.
GROUND/BOND TO GRO UND ALL VESSELS WHEN (ING 18)

Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR RESPIRATOR WITH
DUST, MISTS AND FUME FILTERS (TO REDUCE POTENTIAL FOR INHALATION
EXPOSURE IF USE CONDITIONS GENERATE VAPOR, MIST OR AEROSOL AND
ADEQUATE VENTILATION (E G OUTDOOR OR WELL-VENTILATED (ING 22)
Ventilation:LOC EXHAUST VENT, ENCLOSED SYS DESIGN, CONTINUOUS
MONITORING DEVICES, PROCESS ISOLATION & REMOTE CONTROL MAY BE USED.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
SUITABLE PROTECTION CLOTHING, FOOTWEAR.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
FIRE FIGHT PROC:CNTNRS COOL W/WATER FOG/SPRAY TO PVNT RUPTURE DUE TO
EXCESS HEAT. HIGH PRESS WATER MAY SPREAD PROD FROM BROKEN CNTNRS
INCR CONTAM/FIRE HAZ. DIKE FIRE WATER FOR LATER DISP. SO NOT ALLOW
CONTAMD WATER TO ENTER WATERWAYS. FIRST AID PROC:PATIENT WILL
PERMIT INDUCTION OF VOMIT/EVAC OF STOM. NEVER (ING 6)

Spec Gravity:1.08 @ 25C
Evaporation Rate & Reference:NOT KNOWN
Solubility in Water:INSOLUBLE
Appearance and Odor:THICK, WHITE PASTE WITH A SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, STRONG OXIDIZERS, STRONG BASES, METAL SALTS, REDUCING
AGENTS & ACCELERATORS.
Stability Condition to Avoid:MAY DECOMPOSE IF EXPOS TO TEMPS >131F
(55C). FOR MORE SPECIFIC INFORMATION ON CNDTNS TO AVOID CONT NEHC .
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
BIPHENYL.

Waste Disposal Methods:THE CHARACT OF REACTIVITY PER RCRA WOULD BE
EXHIBITED BY UNUSED PROD IF IT BECOMES WASTE MATL. EPA HAZARDOUS
WASTE NUMBER OF D003 WOULD BE APPLIC. CNTNRS SHOULD BE DRAINED OF
RESIDUEL PROD BEFORE DISP . EMPTY CNTNRS SHOULD BE DISPOSED OF
I/A/W(ING 14)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.